The most common utilization of solid fuel biomass is direct combustion with the resulting hot flue gases producing steam in a boiler—a technology that goes back to the 19th century. Boilers coal fired burn a variety of fuels and continue to play a major role in industrial process heating, commercial and institutional heating, and electricity generation. Industrial boilers are differentiated by their configuration, size, and the quality of the steam or hot water produced. Power plant boiler size is most often measured by the fuel input in MMBtu per hour (MMBtu/hr), but it may also be measured by output in pounds of steam per hour. Because large industrial boilers are often used to generate electricity, it can also be useful to relate boiler size to power output in electric generating applications. Using typical coal fired boiler and steam turbine generating efficiencies, 100 MMBtu/hr heat input provides about 10 MW electric output.

In order to promote technological progress and sustainable development, improve environmental quality and protect public health, recently, the Liaoning Provincial People's Government of air pollutants for coal-fired power plants developed specific criteria (hereinafter referred to as the "standard"). This is the first time a set of policies Liaoning Province for air pollutant coal power plant.

"Standard" provides for pollutant discharge limits, surveillance and monitoring requirements within the jurisdiction of coal-fired power plant in Liaoning Province atmospheric and fugitive emissions control requirements. Since the implementation of the standards, air pollutant emissions coal-fired power plants all within the jurisdiction of Liaoning Province will be executed in accordance with the provisions of this standard.

2, since January 1, 2019, the emission limits of existing single output and more than 300MW generating units supporting the provision of a coal-fired power generation boilers execution table.

3, since 1 December 2020, the emission limits of existing single output 300MW generating units supporting the coal-fired power generation boilers and other power boilers as specified in Table 1 execution.

Sampling the exhaust gas (1) power plant, to be carried out in a predetermined position in accordance with the type of monitor emissions monitoring contaminants. In the discharge of pollutants should be set up to monitor the position of long-term monitoring holes, sampling platform and related facilities. When the sampling platform height from the ground greater than 40m, should be set by a lift platforms, lifts or other convenient and safe facilities. No elevator or elevator building coal-fired power plants, when the sampling platform height from the ground greater than 20m, should be set up safe, convenient electric monitoring equipment hoisting facilities.

Composition structure (3) continuous monitoring system atmospheric pollutants, technical requirements, test items, test methods and installation, commissioning, acceptance, operation management, data processing, etc. according to the provisions of HJ75 and HJ76.

(5) continuous monitoring system meter of air pollutants detection sensitivity, detection limit, and should meet the range of low concentrations of pollutant emission monitoring technical requirements, the concentration of nitrogen oxides include nitric oxide (NO) and nitrogen dioxide (of NO2), Determination of nitric oxide only has the ability to configure the analytical device of nitrogen oxides NO2 / NO converter.

(7) for coal-fired power boiler emissions of air pollutants sampling monitoring, sampling frequency, the sampling time and the operating load requirements,, HJ / T397 and related predetermined low exhaust gas concentration monitoring is performed according to specifications GB / T16157.

(9) shall be in accordance with the provisions of the enterprise "Environmental Monitoring and Management Measures" and the HJ819, HJ820 requirements of pollutant emissions and its impact on environmental quality around to conduct their own surveillance, monitoring and save the original records, public information.

Determination of air pollutants fired power plant analysis are shown in Table 2. After the release of the present embodiment national standard method of monitoring criteria pollutants, such as applicability to meet the requirements, the same applies to the determination of the corresponding standard contaminants present.

2, responsible for overseeing the management of this standard by the executive authorities and the standardization of administrative departments above the county level environmental protection. The results of the environmental protection departments at all levels and other relevant units in the enterprise supervision and checks can be instantly sampled or monitored the scene as determining whether acts of sewage meet emissions standards based on the relevant environmental protection and the implementation of management measures.

The solid fuel fired and biomass fired boilers are mainly used in hotel, hospital, university, central heating, refineries, utilities, petrochemical, chemical, paper and pulp, steel and iron, food processing, power station, and other major processing industries. Solid fuel boiler is chain grate type boiler burning coal, biomass or mix-firing both. It adopts membrane water wall, with economizer in the rear of boiler. High combustion efficiency, energy saving and low emission. Three-pass tube design incorporating a wet back turnaround that eliminates the need for rear door refractory. Larger steam disengagement area providing high quality steam, larger steam storage capability for quicker response to sudden steam demand. Equipped with PLC-based control system to realize automatic operating in start-up, standby and shutdown control Designed, constructed and stamped in accordance with the requirements of the American Society of Mechanical Engineers.

ZG manufacturedcoal fired power plant boiler in Serbia is also popular. One reason is that Serbia has abundance of coal. Serbia is net exporter of electricity and importer of key fuels (such as oil and gas). The other reason is because of ZG Boiler’s ability on boiler manufacturing. Our ZG Boiler has more than 70 years experience on industrial coal fired boiler producing and we has wide prducts such as coal fired boilers, coal fired steam power plant 15 ton industrial biomass steam boiler for textile factory high quality, biomass fired steam boiler, gas fired steam boiler, oil fired steam boiler, CFB boiler,etc. We can meet all requirements from Serbia industrial business. Here is new system coal fired steam boiler in power plant in Serbia.