horizontal water tube boiler for aquaculture industry
When the horizontal water tube boiler for aquaculture industry operation, the reason of maintaining the water level in the normal range: the boiler drum water level is too high, will affect the effect of water separation, the wet saturated steam fraction increases, increased salinity, and likely to cause wall superheater Steam Turbine sCALING stream, superheater flow area decreases, the resistance increases, to improve the heat resistance, the wall-temperature, and even burst pipes; the other also result in increased moisture vapor turbine efficiency is lowered, increasing the axial thrust and the like. Serious water superheated steam temperature over a sharp decline in the steam piping and steam turbine to generate water impact. Cause devastating accidents.
Recently, the Guangzhou City issued an action "Guangzhou 2018 annual work plan for comprehensive prevention and control of air pollution," the bureau of law enforcement to monitor the detachment on August 28 = 29 organizations launched a special enforcement action against a biomass horizontal water tube boiler for aquaculture industry.
The special enforcement action by the municipal and district levels of environmental protection departments jointly launched, deployed Yuexiu, Tianhe, Haizhu, Huangpu, Conghua five district environmental protection law enforcement backbone, with the Guangzhou City Environmental Protection law enforcement inspection detachment composed of 18 cross-law enforcement group, to increase the city all registration to carry out quality checks of 125 biomass boilers in the book, focus on examination of Guangzhou boiler emissions monitoring system in Zengcheng District registered the existence of complex biomass boilers coal or other high-polluting fuels, whether there are special furnace and supporting bag dust removal facilities, whether the normal operation of the boiler control facilities, whether discharge standards as required entry and update Guangzhou boiler emission monitoring system and other issues.
After verification, the registration system by the city list in the boiler has been disabled (off or relocated) boiler station 43, not included in the other eight found regulatory list table 133 actually inspected. Among them, 28 units involving suspected violations accounted for in the boiler problem with the boiler (90 units) ratio of 31%, the problem of coal-fired boilers in complex 2, the resurgence of firewood, 11, allegedly did not apply for environmental protection procedures, waste gas treatment is not installed facility or facilities are not the normal use and other illegal activities 15. For complex high-polluting coal and wood fuel boiler according to law-site seizure and transfer penalties and territorial environmental protection departments to follow up treatment in accordance with the relevant provisions of Article 107 of the "People's Republic of China Air Pollution Prevention Law." The rest were arrested for illegal transfer of territorial environmental protection departments for investigation.
Each unit using gas horizontal water tube boiler for aquaculture industrys, boiler operation for daily consumption are very high value, because only the cost control certain limit, in order to obtain more benefits. Gas consumption is a measure of the extent of energy benchmark gas boiler, gas boiler fast Boiler condensation using advanced technology, can effectively reduce the exhaust gas temperature and improve the thermal efficiency of the boiler.