2000kw industrial steam boiler
Working principle of steam-steam separation unit on 2000kw industrial steam boiler
In the overall design of steam boiler, the steam separation device is essential, it is an important link to quickly separate the moisture contained in saturated steam, which can be used to improve steam dryness and ensure the normal operation of the boiler. Convenient and meet the needs of users. Then, I will lead you to understand the steam boiler steam separation unit working principle.
When we use the gas boiler cleaning and maintenance is very important that we first open the burner door in the use of gas-fired boiler, remove the rear housing panel, tighten the screws to open the rear side of the boiler clean mouth. Clean fuel gas piping with a wire brush. With a soft brush to clean the combustion chamber. Gas boiler to remove residue in the boiler, the cleaning opening is screwed on the screw, closing the burner door seal check is complete. If the boiler is installed in areas where temperatures below 0 ℃ must take the following precautions: If outside the boiler room, the room temperature drops below 15 ℃ or 18 ℃, the whole day operation of the boiler. If a long time no one in the room should be emptied of water in the boiler. You know cathodic protection of each member constituting the boiler (such as iron, copper, aluminum, etc.) of different materials. In order to prevent galvanic corrosion, cathodic protection measures must be taken. Sewage treatment boiler. The bottom of the gas-fired boiler flue gas emissions to prevent condensation. Since the flue gas is flue gas condensation (diesel or natural gas) and the flue gas temperature in the aqueous too low, water generated. A portion of the moisture is discharged from the chimney, the chimney wall is absorbed, the rest is deposited on the bottom of the chimney. Water produced by the following factors influence: flue gas temperature (efficiency 91%, the flue gas must be at a temperature of 170 ℃) where the total surface area heat chimney, chimney and chimney material. Maintenance of the burner. Gas boiler and burner maintenance, the best maintenance after steam supply. Because the products of combustion will corrode the boiler, clean up carbon deposits, therefore, not allow the products of combustion in the boiler memory stay too long.
economizer in boiler
The economizer is a device installed in the lower part of the flue of the boiler to recover the waste heat of the exhausted smoke. The boiler economizer is a tube heat exchanger located in the final part of the convective duct. In the economizer, water flowing into the boiler is preheated by flue gases. In boilers, economizers are heat exchange equipments that heat water to a temperature close to boiling point. Economizers make use of the enthalpy in the hot streams. Because the streams are usually still not hot enough to be used in a boiler, economizers recover the more useful enthalpy and improve the boiler's efficiency.
It is reported that Haidong Qinghai positive response to the central problem of coal-fired boilers environmental supervision feedback rectification work, to speed up the production of green, zero emissions work processes, and improve air pollution control plan before the end of 2020, out of the central regulation of environmental inspectors feedback 10 tons of steam coal-fired boilers and 35 sets of Haidong since 2013, new registrations per hour.
Haidong county (district) government to fulfill the main responsibility for the area out of small coal-fired boilers, in accordance with their respective administrative areas, to develop the county (district) phase out remediation work plan. A thorough inventory of all the region under pressure coal-fired boiler to install and use cases, and register, identify all cases remediation coal-fired boilers since 2013 new registrations do not meet the requirements, filing one by one. It urged all localities to fully consider the urban built-up area, divided ban on burning areas, local conditions, facilities strategy, apply non-urban area Haidong 20 tons of steam per hour, new coal-fired boilers, and establish normal management mechanism. Meanwhile, arrangements for the rectification of funds, and actively apply for provincial, municipal, county departments of special subsidies, to ensure the implementation of coal to gas coal to electricity, coal-fired boiler, new alternative energy and other projects, and with the central environmental inspectors feedback registration illegal small coal-fired boilers problem rectification work combine to promote the problem has been effectively solved.