WNS horizontal heavy oil fired steam boiler
SZS wns horizontal fired steam boiler capacity is among 4 ton to 35 ton; WNS steam boiler capacity is among 1 ton to 20 ton. We also supply gas and oil fired power plant boiler. Higher capacity steam boiler is also in our product lists. Just I do not writeit in this passage.
Steam boiler rules Henan fast boiler with small series to introduce the company's wns horizontal fired steam boiler operating procedures. First, the components of the steam boiler before oven cooking oven and check (a) and oven cooked boiler furnace must be checked in detail. Check the following items: 1, cold chain grate test more than 24 hours, cold test should meet the following requirements: (1) grate should be smooth turning chain wheel axle, found arched, two tension bolts can be tightened. (2) the active grate sprocket good occlusion. Minimum gap (3) on both sides of the active grate block with the side seal and the side seal angle not less than 6 mm. Distance (4) on both sides of both ends of the furnace grate platoon leader pin in the sprocket should be kept equal. If it is found at one end to the occurrence of side friction, long waist-hole may be a tap with a hammer, the end surfaces on both sides remains equal distance. (5) steam boiler grate rotated without jamming, deviation phenomenon, when the deviation found by the inspection hole into the rear grate tail, the tie bolt align the two bearings of the drum, deviation phenomenon can be eliminated. The boiler has ignition combustion, still need to transfer found Hearth n, just before two adjustable chain tensioning bolt shaft directly outside the furnace, but preceded align the front sprocket shaft and a gearbox connect the safety pin or bolt removed until after squaring shaft to a gearbox with a chain alignment pin or bolt after tightening, may otherwise result in misalignment with the sprocket shaft of a gearbox and mechanical damage. (B) Check broken grate furnace platoon leader pin is bent, if long waist hole in the furnace may be carried out at any time platoon leader pin alignment reload. (C) a chain grate does not allow foreign matters (such as bolts, nuts, nails and other iron) is present. (D) firing door open and flexible, easy to open and drop the shutter coal, coal gate left and right side of the grate surface distance equal to, the thickness of both sides of the seam to ensure equal furnace, as a method for reducing ranging from links available to make equal, coal shutter cover plate should cover tightly to prevent leakage into the coal, coal stuck shutter. (Five) of each grate windshield of smoke damper and damper adjustment inside the flue flexible switch. (Vi) blower, Fan, Java machine, commissioning normal water supply equipment. (Vii) manhole, hand hole is tight, attached parts fitted Ge are complete. (Viii) the furnace wall is normal, the flue is tight. (Ix) steam boiler pipes, water pipes, sewage road is complete. (J) all filled with lubricating oil in the bearing housing and oil cup. (Xi) All electrical equipment should be empty running test, inspection equipment, and other electrical lines is intact.
Cause of the high energy consumption of electric wns horizontal fired steam boilers through a lot of practice and testing, has made great progress in terms of a unified understanding of the design and practice getting closer and closer. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass hot water boiler, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. There are heating and hot water boiler bath for two purposes. Hot water boiler by circulating hot water circulation pump hot water holding tank, the tank hot water heating cycle can be achieved bath object; hot water boiler by circulating hot water circulation pump heating conduit, through the heat sink (radiator) people can achieve heating requirements; hot water boiler and hot water circulating pump with heat exchanger can be achieved bathing and heating dual function. Currently, electric steam boiler heating operation and management, divided into two categories: professional management and unit housing construction sector management itself, the management level is generally low. Professional management in good condition, a few self-management units at a high level, in the most basic high energy consumption, low efficiency of state. In addition, widespread attention heating social benefits, but energy-saving consciousness, the application of new technology, new achievements of small, long-term stay on the extensive experience of management, not to the level of refinement of scientific management. For a long time, in the development plan, the electric heating steam boiler, a new, integrated planning joint planning of lack of awareness. Residential construction and use of all available space, scattered along the road of small hot water boiler room has become a matter of convenience. Form a compact electric steam boiler steam boiler and a small capacity electric power consumption is large electric steam boiler birth defects. Forming two small facts, and indeed closely related to the lack of unified planning, but also because of lack of planning and hard to avoid blindness. In the past for a long period of time, various safety considerations due to the heating of the design, the design heat load calculation results generally much larger than the actual required value. Therefore, the emergence of the world's more than a radiator, electric steam boilers, large pumps, large diameter of the situation, the mainframe carriage pull carts situation in the world, the phenomenon of low load, the flow is widespread. This is because the designers of the factors affecting the heating of insufficient knowledge, poor operations management such as heating, furnace workers low level of technology. They worry that heating is not hot enough, dare reduce the thermal load, resulting in equipment is still too large, creating a vicious cycle.
In recent years, Hebei Province People's Government to respond positively to Blue Sky Battle action plan promulgated by the state, and all of 35t / h coal-fired boiler and below in the Hebei province out of the transformation process. First Hospital of Baoding respond positively to the call of the provincial government, eliminate serious pollution of the original coal-fired boiler hospital, citing energy saving wns horizontal fired steam boiler to natural gas as raw material. After a series of market research, WNS Series Split hospital condensing gas boiler boiler other fast soft spot.