alstom thompson coal fired steam boiler for sale
Coal-fired alstom thompson coal fired steam boiler for sale scale can cause harm and failure scale is the first coal-fired steam boilers, coal-fired steam boiler is the main cause of the accident, the danger main problems: wasting a lot of fuel: Because the thermal conductivity of the scale of only a few steel one tenth, so that the heating surface when the fouling of heat transfer will hindered, in order to maintain a coal-fired steam output, it is necessary to increase the temperature of the side of the fire, so that the external radiation and flue gas heat loss. Now can be used efficient and environmentally non-corrosive cleaning agent fired steam cleaning, expose the metal tube so that the device primaries, and to reduce biological fouling of algae because silt impact. While the peeling effect of iron on the iron oxide and ethylene, prolong the service life of coal-fired steam boilers, to reduce energy consumption and improve productivity. Fired steam after a long run, the inevitable emergence of scale, the problem of corrosion, scale coal-fired steam boiler formation is mainly due to the water with hardness components, high temperature, high pressure after continuously concentrated by evaporation, the coal-fired steam furnace with a series of physical, chemical, and finally heating surface to form a hard, dense scale, resulting in reduced heat transfer and the effect of corrosion under the scale factors, leads to a reduction endothermic coal-fired steam boiler waterwall furnace, burning coal steam boiler furnace exit temperature increases, the increase in the loss of coal-fired steam boilers. After scaling while reducing the heat transfer within the water wall, water wall tube wall temperature may lead to increased water wall lead to burst pipes, affect the safe operation of coal-fired steam boilers.
A number of national influence energy consumption alstom thompson coal fired steam boiler for sale coal to natural gas has been vigorous work, it should be transported steam boiler, very big eliminate the dust pollution, discharge of toxic gases and secondly nitric oxide, also got curb. Energy consumption is crucial mark measuring steam boiler, a good start and that is that work together to explore under the influence of a number of cases the energy consumption of steam boilers. Through the investigation of the persons concerned, the loss of heat from steam boilers bear the main two areas: combustion air-fuel ratio does not smoke emissions standards-related heat loss. Reduction of heat loss will install smoke emission in the flue gas heat recovery steam boiler terminal fitting, or should be transported more leading type condensation recovery boiler. Combustion air-fuel ratio standard fault summary: a conventional steam boiler burner ejector type, formed air-fuel ratio can not occur motorized adjustment. Some of the steam boiler with a mechanical blower burner, causing air-fuel ratio standard there are several aspects later: the main air-fuel ratio standard case encompass fall into two categories: air flow when exceeded, there will be an endless excess cold heat transfer, resulting in high energy cost of steam boilers, steam boilers reduced energy consumption; when the airflow is not enough, will have not exactly lit, the energy consumption caused by steam boiler weakened.
We learned from Anshan City Bureau of the ecological environment: to improve air quality living environment for urban residents, according to government requirements, Anshan external publicity of the built-up areas and industrial parks and a list of more than 10 tons of coal-fired boilers, municipal environmental protection department also welcome all citizens supervision, to provide the city's built-up areas and 10 tons and above boiler clues industrial park outside the list.
Battle to lay the blue sky, the city has in recent years embarked on a built-up area and the city's industrial park and 10 tons of coal-fired boilers out of work, the city built-up areas and industrial parks and 10 tons of coal-fired boilers demolition of all the reservation coal-fired boilers to achieve discharge standards. As requested, before the end of 2020 in the city of Anshan City will be built-up areas and industrial parks all phase-out over 10-20 tons coal-fired boilers, coal-fired boiler units involved should be prepared in advance.
To further enhance the quality of atmospheric environment, promote environmental management to raise the overall level, in accordance with the requirements of the provincial government, the city of the city within built-up areas and industrial parks and more than 10 tons of coal-fired boilers information for publicity. These publicity boiler will be included in the list of key sewage units, strict supervision, to ensure the discharge standards.
Gas-fired alstom thompson coal fired steam boiler for sale, gas steam boiler buy several natural gas boiler should pay attention to, the purchase of natural gas boilers points to note from the National Development and Reform Commission learned that China's coal to gas steam boiler is widespread promotion of the implementation, will enter a stage of comprehensive reform. Xinjiang is about to be the most important work to complete the rectification, the rectification process of the Central Plains and northern regions also increased the intensity and speed of more than 40% of the coal-fired steam boilers, gas-fired completed the replacement of the country. At this stage there are a lot of users need to buy gas-fired boilers to meet the current national environmental policy, I would buy natural gas boiler problems and the majority of users to exchange views in order to buy the rest assured, with satisfaction. First and foremost do with the current coal-fired steam boiler model number and tonnage, boiler gas production and steam pressure that is being used enough, if we can current production, gas production and pressure on the election of equal size gas steam boiler, if not enough or barely enough, you need to choose a slightly larger model of boiler is the second point you are ready or the near future to expand the scale of production, it is necessary to recalculate gas production gas steam boiler, steam boiler of the gas production and future production scale be able to adapt. I met a lot of friends only consider the current, do not consider the needs of the next few years, thinking only meet the current needs on the line, such as the expansion of production and back. The ideas and practices to create a lot of trouble later, the life of a gas steam boiler is probably about 15, you do not have to change a few years, it is only used when processing a lot of losses. Furthermore, the replacement process is very time-consuming, to re-install the application procedures go again, and delayed production. Do not take precautions, you will regret it. The last thing to note is to ensure that the opening of the gas pipeline, if your area has no natural gas pipeline, is to buy a gas steam boiler also spend the. In determining the purchase of gas-fired, the first not to rush to the boiler transported to the site, first opened gas pipeline things well. A client told me: "I opened a mouth, a natural gas company gave me to do 100,000 a month just to run." So, first hit the point about the relationship, try to spend less money to natural gas mouth opened, then natural gas boiler shipped home.