Coal Fired Boiler 500Kg
Since Prime Minister Li Keqiang in the "five" proposed "Blue Sky Wars," after the strategic plan states that China provinces and cities are doing to improve environmental protection. Jilin Provincial People's Government recently issued a "Jilin Province to implement the winning Blue Sky Battle three-year action plan to implement the program," coal-fired units will conduct a comprehensive reform.
Jilin Provincial People's Government recently issued a "Jilin Province to implement the winning Blue Sky Battle three-year action plan to implement the program" (hereinafter referred to as the "Program") said that before the end of 2018, the province's 300,000 kilowatts or more coal-fired units completed ultra-low emissions transformation. Continue to promote the 200,000 kilowatts class ultra low emission coal-fired unit renovation project, before the end of 2019, ultra-low emissions and strive to transform the province's total unit capacity of thermal power capacity of more than 75%.
"Program" also proposed to complete the transformation of ultra-low emission electricity generation units appropriate to increase the number of hours. Vigorously for shutting down environmental protection, energy consumption, safety and other 300,000 kilowatts coal-fired units of non-compliance. Coal-fired generating units to increase the technological transformation efforts, speed up the heating pipe network construction, fully release and improve the heating capacity, eliminate coal heating boiler pipe network coverage and the range of loose coal. In areas do not have the cogeneration district heating conditions, the existing multiple small coal-fired boilers, alternative construction of large-capacity coal-fired boilers in accordance with the principle of equal volume. Before the end of 2020, within a 15 km radius of 300,000 kilowatts of heating and cogeneration power plant above range, in the case of cogeneration heating load to meet the heating needs, in addition to the need to retain the peaking boiler, coal-fired heating boilers and small coal-fired thermoelectric behind all closed down integration.
In addition, long-term control of total coal consumption in accordance with planning requirements, Jilin Province, to continue to reduce the amount of coal consumption, coal consumption in new coal projects to implement alternative reduction, by 2020, reduce the proportion of coal accounting for the province's total primary energy consumption to 63% the following. According to focus on the use of coal and clean use of principles, focusing on reduction of non-power coal, increase the proportion of electricity from coal, the state-assigned task is completed, the province's electricity by 2020, the proportion of thermal coal coal consumption reached more than 55%.
In the future, the province will carry out a comprehensive environmental aspects of governance, economic development and environmental protection go hand in hand.
ZG is in the forefront of the domestic research on energy saving circulating fluidized bed coal fired boiler 500kg, ZG with a boiler manufacturing license, "ASME S", "ASME U" stamp, is a large state-owned enterprise, after 70 years of development, in the national and international scope to establish a good brand image, with annual production of power plant boiler, industrial boiler (coal, oil and gas, biomass), 12000 tons of waste heat steam boilers, pressure vessel,more than 16000 tons of metal and other 9 series more than 200 varieties of production capacity.
Operation of a gas coal fired boiler 500kg gas boiler in Henan related to maintenance, the ignition operation, fire, shutdown and some other operational measures: First, the gas boiler maintenance Henan, operating procedures should be required to carry out tests on the gas transmission main boiler protection devices, ensure that the main protection correct action. Second, the ignition process Henan gas boiler, fuel pressure, fuel temperature, steam pressure atomization, atomization steam temperature and other parameters must meet the requirements of operating procedures, good place to observe oil gun fire, fire detection return to normal, prohibit short-energize inspection signal forcibly put into the oil gun running. Single oil gun when the flow is greater than 0.65kg / s, exit the gun should be run immediately. Third, observe boiler ignition temperature rise rate of fire smoke significantly Pianman furnace flue gas temperature of the main steam temperature, steam pressure rises when the main, the case of smoke or boiler ignition temperature did not rise immediately to check the opinions of the oil gun, if No fire was found after the fuel into the furnace, emergency shutdown, re-ventilate the furnace purge Do not allow to run into the boiler ventilation oil gun. Fourth, note that starting mill to check whether the subject returns normally coals, coal mill outlet temperature of greater than 70 deg.] C line is allowed to increase the amount of coal (three grinding mill operation start of the fourth stage, the coal mill outlet line than 80 ℃ temperature allowed to increase the amount of coal, to prevent excessive vibration furnace). Full stop before the gun when the present discharge amount of coal is increased 5.0kg / s or more. 6.3.5 Operating Henan gas boiler, "furnace black", "lose the protection of the main fuel" must be put into operation as required operating procedures. In case of a fault protection device itself appears to be temporarily out of operation, to be approved by the competent manager or chief engineer before implementation. "Furnace black", "main fuel unprotected" means the period out of operation, priority monitoring attendant to furnace pressure, the oxygen, the main steam temperature, the main steam pressure and other parameters, and through the furnace of fire industrial television monitor, and if found hearth fire, emergency shutdown. Sixth, Henan gas boiler normal operation, the fuel system and oil spare gun good condition, found that boiler combustion instability immediately put oil combustion. Seven, after Henan gas boiler fire, into the oil gun is strictly prohibited without the operation of the boiler ventilation. Eight, gas boiler has confirmed the fire, when the MFT is not operating, emergency shutdown, and check that the two primary air fan, 4 mill, 16 oil gun has stopped running. Back nine, Henan gas boiler trip or normal shutdown to be purged immediately ventilate the furnace, the furnace unburnt coal dust and combustible gas pumped in a timely manner. And promptly shut down the boiler supply and return oil total gate manually to prevent leakage of fuel oil gun into the furnace. Ten, Henan gas boiler shutdown purge gun ban mill and pulverized coal into the furnace exhaust.
Boiler distributors & manufacturer in UAE
UAE have many industries which need boiler for example sugar plant, textile plant, cement plant, aac block plant, etc. Steam boiler is important equipment in industrial processing, ZG Boiler is the industrial boiler leader manufacturer and supplier in China. We supply many types boiler, there are gas & oil fired boiler, coal fired boiler, biomass fired boiler, waste heating boiler, CFB boiler power plant boiler, AAC autoclave.