24mw coal fired power boiler
Gas-fired steam boiler in the use, operation is very convenient, so will much favored by all walks of life. Because the use of all natural gas pipeline, a sustained run without any problems. Eliminating the need to transport coal use and clean-up or stacking cinder and other tedious work.
4. Clean the reason why gas steam boiler in the market to get a high rating, but also because it is clean and not contaminated during use, and does not produce black bottom of the pot, there is no air pollution. Thus, in use, compared to other boiler is the cleanest way.
Today I saw that when the capacity is the same, the furnace of the oil-fired 24mw coal fired power boiler is smaller than that of the coal-fired boiler. Why? The specific reasons are as follows: the size of furnace volume, after the boiler capacity is determined, mainly depends on the volume of heat load. The size of the volumetric heat load is mainly determined by the type of fuel. After the fuel enters the furnace, it will take a certain amount of time to burn out. Fuel is usually required to burn out before it leaves the furnace. It is obvious that pulverized coal will burn longer than oil, that is, the flame of coal combustion will be longer than that of oil. In order to ensure the long-term safe operation of the boiler, it is necessary not only to prevent the slagging of the boiler, but also to make the temperature of the flue gas at the furnace outlet begin to change compared with the ash in the flue gas The temperature is 50 ℃ lower than 100 ℃ to prevent slagging at the furnace outlet and subsequent convection heating surfaces. The ash content of coal is more than that of coal-burning furnace, and the flue gas temperature of furnace outlet is 1050 ℃ and 1100 ℃. There is no danger of slagging in the furnace because of the low ash content in the oil, and do not consider the slagging problem of the slag discharge tube at the exit of the furnace, so the smoke temperature at the exit of the furnace can be higher.
Steam 24mw coal fired power boiler heating in winter north of the advantages and disadvantages of our country, cold weather, heating is essential, often used before coal-fired boilers for heating, but coal-fired boilers to serious air pollution, now gradually replaced by steam boilers. Steam boiler is also very common type of heating equipment, are now gradually penetrate to the south. Steam boiler heating both advantages and disadvantages, we compare: first, an analysis of the advantages of using pulverized coal combustion boiler, the coal is in fact relatively high temperature, the surface temperature of the steam boiler is relatively rapidly increased, but in fact, this system can withstand particularly low cooling system. 2, the steam in the evaporation process, as in fact it is the gas density is quite small, for which the net pressure steam boiler itself is relatively small. 3, the steam itself does not require any external pressure resistance of the propulsion system for it. 4, steam boiler has a clear advantage, the heating effect and very fast, but it stopped gas speed is faster, especially for users of intermittent heating. Second, an analysis disadvantage, during use in a steam boiler, because the pipe is relatively high stability, and is not easy to heat, in the course of prolonged use, the dust around the surface of the device, so that the relatively poor surroundings, and heat slowly dispersed, easy to burn people. 2, in a more simple production conditions, the use of the boiler does not care, and the system will cause leakage particularly large heat loss, so that the waste of energy is relatively more serious. The disadvantage of steam boilers we could have been avoided, in use of the process will be seriously careful to avoid being burned or wasted energy.
2018ISH heating HVAC industry event, fast Boiler "Thalia T7" was set aside to hold the event May 23, ISHChina & CIHE China (Beijing) International heating ventilation air conditioning, heat pumps fresh air and home comfort systems and technology exhibition in Beijing International Exhibition hot center opening.