0 5 ton to 30ton horizontal oil steam boiler
November 22, Henan Vice Governor Mr. Liu Wei and his party more than 40 people, accompanied by the main leaders of Anyang City, the plant reaches the plains to visit our company guidance. Group R & D center for aspects of digital exhibition hall, laboratories and clean the boiler plant manufacturing plants and other intelligent devices to inspect. Group President Lu Haigang as a representative of a warm welcome to the guidance of the leadership team, and to explain to the whole delegation.
2. szs series oil/gas boiler
The SZS is a modern D-type water tube boiler design, with gas tight membrane wall construction for all furnace walls including the front wall to maximize heat transfer. Tube manipulations for burner and man door penetration maintains optimum circulation. Two stage separation within the steam drum ensures high quality steam.
The scaling of gas-fired 0 5 ton to 30ton horizontal steam boiler not only reduces the thermal efficiency of the boiler, but also increases the temperature of the heating surface of the boiler, causes damage to the heating surface, and even causes the explosion accident of the boiler. Therefore, the use of soft water treatment equipment, strictly according to the process operation of boiler feed water softening treatment equipment, control boiler feed water quality, can delay the formation of the scale. At the same time, it is very important to control the boiler scale in real time, master the boiler scale and clean the scale if necessary. Because the temperature of the gas-steam boiler body and the steam-water heat pipe system is higher than the air temperature in the boiler room, some of the heat is emitted through radiation and convection into the surrounding air. This becomes a loss of heat. Boiler Therefore, the heat loss should be reduced when the heat insulation and heat pipe system of the boiler are damaged or leakage is discovered. The increase in noise from gas-fired steam boiler burners is mainly due to the closure of the valve or insufficient oil intake in the oil path, blockage of the oil filter, or because of low inlet temperature, high viscosity or oil on the pump. Too high temperature; oil pump failure; fan motor bearing damage; due to dirty turbine impeller, the equipment is too loud. This failure occurs when a gas-fired boiler is in use and is not easy to atomize (heavy oil) because of the high viscosity of the oil; it is also due to cyclone and jet The distance between the nozzles is inappropriate; in addition, because the burner is worn or dirty; it is also due to the excessive heating temperature of the spare fuel tank, resulting in steam pumping the oil pump out of the oil pump; or because the oil in the oil boiler is hydrated. Gas steam boiler feed water contains a variety of impurities and calcium, magnesium and other scaling substances, the boiler will inevitably expand. The thermal conductivity of the scale is very low, so once the surface is polluted by the hot surface, the exhaust temperature of the boiler will increase, and the heat loss of the exhaust gas will increase due to the increase of the thermal resistance. The experimental data show that the heat loss of waste gas will be increased by about 2%-4% when 1mm oxide is formed on the heating surface of boiler. The thicker the scale on the heating surface of the boiler, the greater the thermal resistance, and the lower the thermal efficiency of the boiler.
A, WNS series automatic fuel (gas) 0 5 ton to 30ton horizontal steam boiler 1, an internal combustion boiler using a horizontal double quick return smoke wet back structure, the body-mounted using the waveform furnace, combustion chamber and back to the waveform furnace, connected to threaded pipe. After exotherm temperature flue gas flame in the furnace, carried to the threaded pipe via the folded back to the combustion chamber to the convection heat before entering the smoke chamber; high temperature flue gas enters the condenser back energy, the heat transfer by sufficiently by chimney into the atmosphere. 2, for a variety of boiler fuel oil, natural gas fuel, city gas or liquefied petroleum gas. 3, the boiler before the smoke box with movable lid cigarette, demolition, convenient rear access. Boiler with integrated burner, has started fast, high efficiency, high degree of automation features, the need to provide for a variety of local life, civil and industrial steam. 4, a boiler with full instrumentation system valve, the valve body has a boiler inlet valve, check valve, the main steam valve, safety valve, drain valve, air valve and the combustor brought solenoid valve. Water meter with a measuring point pressure display, display and control drum pressure, exhaust gas temperature display, the temperature and pressure of the burner is displayed. 5, combustion and boiler feed water using automatic control, automatic adjustment, easy operation, low labor intensity and safe and reliable protection devices, easy maintenance and repair.