6mw gas fired thermal oil boiler
Recently, Heze City, Shandong Province issued the "implementation of Heze City
1, adjust and optimize the industrial structure, strictly control the "two high" industry capacity. And resolutely put an end to "scattered dirt" projects and has been banned "scattered dirt" off-site transfer business. Since October 1, 2018, thermal power, petrochemical, chemical, carbon, industrial boilers and cement and other industries, the implementation of air pollution emission limits in particular, to promote pollution control in key industries.
2, speed up the adjustment of energy structure, promoting clean efficient heating. The pooling of resources and vigorously promote the coal for governance, before the heating period in 2020 basically completed the life and motivations of heating coal for alternatives to achieve the task of clearing the loose coal. Is expected before the end of December 2018, the urban built-up areas out of 35 steam tons / hour coal-fired boilers, encourages other regions to advance out of 35 steam tons / hour coal-fired boilers. At the same time accelerating the transformation of low nitrogen gas boiler NOx emission after the transformation shall not exceed 50 mg / cubic meter.
The output power of the burner should be matched with the rated output of the 6mw fired thermal oil boiler, and the shape of the flame, such as length and diameter, should be selected to suit the furnace structure. Supply the air needed for fuel combustion from the torch root to make the oil mist or gas and air mix evenly and quickly to ensure complete combustion.
2.4MW YQW gas-fired thermal oil heater for textile industryThermal oil heaters play an important role in the textile industry, providing heat energy for the process of dyeing, drying and printing. Located in Manila (the capital of the Philippines), Pantone Finishing Corporation is a large company engaged in textile products. The rising in natural gas price results in the increases of running cost for original thermal oil heaters. In order to save cost while having no effect on production, the company planned to purchase several energy-saving thermal oil heaters. The thermal oil heater produced by ZOZEN has superior advantages in manufacturing technique, which will guarantee the high quality. In consideration of the actual condition, ZOZEN’s engineer provided the company with YQW series gas-fired thermal oil heater and a tailored-made solution. The thermal oil heater adopts multi-loop coil tube design for safe operation, sufficient heating surface and high thermal efficiency. Furthermore, to achieve maximum effect of energy saving and consumption reduction, the thermal oil heaters are also equipped with waste heat recovery device including heat recovery 6mw fired thermal oil boiler, air pre-heater and economizer. The textile mill was so satisfied with the solution that they ordered several thermal oil heaters.
Which Xining Xining industrial 6mw fired thermal oil boilers industrial boilers looking to find Which? There are a lot of companies need to produce industrial boilers in Xining area, industrial boilers had previously been dominated by coal, but now the purchase of multi-boiler is gas-based. This is also in line with the requirements of the current environmental policy. For the procurement of industrial boiler business, then Xining region, for businesses can be compared within the boiler manufacturers nationwide. The company Xining After initial screening decision Xianxiang fast boiler manufacturers for consultation. In this regard, fast boiler manufacturers for the accounting data for the current production status of the enterprise Xining, concluded that the plant with 1 table 6 tons of industrial gas steam boiler on it. Initially, the company for the transport of Xining boiler still have concerns, however, listened to a detailed introduction side boiler fast personnel of the relevant technology. Completely dispel concerns. At present, the price of the model of industrial steam boiler at around 720,000. Recently, the Xining to fast Boiler companies will conduct field investigation, will talk about specific issues related to time after purchase.