horizontal fire tube boiler for drinks
2, the exhaust arrangement (flue gas) heat recovery.
Exhaust heat recovery from the flue gas passage to increase spray tower, heat exchange by spraying water mixed with the flue gas, a large amount of heat carried away by the fumes spray water, reduced exhaust gas temperature, high temperature spray water is pressurized by the circulating pump through a heat exchanger or other heating boiler return mechanisms, in order to achieve recycling of flue gas waste heat of exhaust gas temperature is reduced, saving energy and reducing the running cost and the fuel. Than the exhaust heat recovery economizer much better energy-saving effect, even some devices may be the flue gas water vapor latent heat recovery. But the exhaust heat recovery unit investment, more equipment, additional operating costs also, the failure rate is high. The economizer is simple and reliable, no mechanical component failure rate, operating costs are zero.
WNS type condensing horizontal fire tube boiler for drinks integrated heat pipe should be easy to lead WNS type condensing boiler should one seek to be close to the area of the heat load is relatively concentrated. Should facilitate the extraction heat pipes, it is conducive to the recovery of condensation water, and placed on outdoor pipes reasonable skill, economy. Local traffic should be located conveniently for easy storage of fuel deliveries, and should make the flow of people and vehicles transporting fuel separator. WNS one type condensing boiler room should be consistent with national health standards, the relevant provisions of environmental standards. We should be able to meet the requirements of water supply, drainage, electricity supply. WNS one type condensing boiler room should have a better orientation in favor of natural ventilation and lighting. Geological conditions should be better situated area. It should help reduce the impact of harmful components of smoke and noise of the surrounding environment. WNS year-round operation of the integrated-type condensing boiler room should be located less dominant side overall frequency of wind direction and priorities of residential area of environmental protection, WNS type boiler room-one condensing boiler should be located inferior side of the prevailing wind season, and should be fit environmental impact assessment requirements set forth proposed. We should consider the possibility of future development. Regional WNS one type condensing boiler room should be consistent with the overall urban planning, district heating requirements planning. WNS integral type condensing boiler is suitably separate buildings.
Since 2017, Yongji County, Jilin Province to respond positively to the State Council issued the "Air Pollution Prevention Action Plan" to carry out corresponding work strictly in accordance with national, provincial and municipal environmental requirements.
It is reported that out of Yongji County vigorously promote the renovation work of small coal-fired boilers, promulgated and implemented the "little out of Yongji County boiler work program" to develop "a furnace policy" policy, no longer approve new steam 10 t / h coal-fired boiler , while promoting the phase-out of small coal-fired boilers.
For small coal-fired boiler phase-out program has been effectively implemented, Yongji County Government has formulated "Yongji County eliminate small coal-fired boiler renovation award up approach", the county built area of active users to carry out remediation work out of coal-fired boilers by small standard for financial awards complement, after the introduction of premium policy, and in the mouth before the town government to convene Yongji economic Development Zone, the area held a small coal-fired boilers user related meetings, arrangements for specific phase-out management work, and to a great extent to promote the progress of small coal-fired boilers eliminated.
Since the initial carry out small coal-fired boiler renovation work in 2017 to the present day, Yongji county built-up areas out of a total of 59 small coal-fired boiler units, a total of 16 sets of 20 tons of steam / hour non-electric and coal-fired boilers intention has been completed to upgrade pollution control facilities renovation work.
CFB horizontal fire tube boiler for drinkss can be dangerous under improper operation. All normal safety precautions should be followed when operating CFB boilers, burners, and fuel systems.Here are some aspects should be kept in mind.